GENERAL INFORMATION
1 - 6
En
ine 450
550
DANGER
Take care not to spill coolant onto hot engine parts and exhaust system. It may ignite and produce
invisible flames.
Wear latex gloves when servicing.
Although toxic, it has a sweet taste that might attract animals. Never leave coolant in open container
or in a position easily reachable by animals.
KEEP AWAY FROM CHILDREN.
Do not remove radiator cap when engine is still hot. Coolant is under pressure and might cause burns.
HYDROGEN GAS AND BATTERY ELECTROLYTE
DANGER
The battery electrolyte is a toxic, caustic substance containing sulphuric acid and thus able to cause
severe burns in case of contact with the skin.
Always wear tight gloves and protective clothes when handling this fluid.
In case of contact with skin, rinse with plenty of fresh water.
Always use a protection for your eyes since even a very small amount of the battery fluid can cause
blindness. In the event of contact with your eyes, carefully wash them with water for fifteen minutes
and then consult immediately an eye specialist.
Should you accidentally drink some fluid, drink abundant water or milk, then drink magnesia milk or
vegetable oil and immediately seek medical advice.
The battery gives off explosive gases and must be kept away from flames and sources of ignition or
heat; do not smoke near the battery.
KEEP AWAY FROM CHILDREN.
Battery fluid is corrosive.
Do not spill it, especially on plastic parts.
Make sure that the electrolyte acid is suitable for the type of battery used.
GENERAL PRECAUTIONS AND INFORMATION
Follow these instructions closely when repairing, disassembling or reassembling the motorcycle or its components.
DANGER
Using bare flames is strictly forbidden when working on the motorcycle. Before servicing or
inspecting the motorcycle: stop the engine and remove the key from the ignition switch; allow for the
engine and exhaust system to cool down; where possible, lift the motorcycle using adequate
equipment placed on firm and level ground. Be careful of any parts of the engine or exhaust system
which may still be hot to the touch to avoid scalds or burns.
Do not put any vehicle parts into your mouth: vehicle components are not edible and some of them
are harmful or even toxic.
Unless expressly specified otherwise, assemblies are reassembled by reversing the dismantling
procedure. Where a procedure is cross-referred to relevant sections in the manual, proceed sensibly
to avoid disturbing any parts unless strictly necessary. Do not polish matt-painted surfaces with
polishing paste.
Never use fuel instead of solvent to clean the motorcycle.
Do not clean any rubber or plastic parts or the seat with alcohol, petrol or solvents. Clean with water
and mild detergent.
Always disconnect the battery negative (-) lead before soldering any electrical components.
When two or more persons service the same motorcycle together, special care must be taken to avoid
personal injury.
BEFORE DISASSEMBLING ANY COMPONENTS
• Clean off all dirt, mud, and dust and clear any foreign objects from the vehicle before disassembling any
components.
• Use the model-specific special tools where specified.
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals